1051
PALM OIL-BASED METHYL ESTER SULPHONATE PREMIXES FOR USE IN DISH-WASHING LIQUIDS
PALM OIL-BASED METHYL ESTER SULPHONATE PREMIXES FOR USE IN
DISH-WASHING LIQUIDSZAHARIAH ISMAIL*; MOHD SURIA AFFANDI YUSOFF* and KHAIRUDIN HASHIM*
* Sime Darby Research Sdn Bhd, 42960 Carey Island, Selangor, Malaysia. E-mail: [email protected]
reasons. They include:
• good lime-soap dispersing characteristics(Yoneyama,1996);
• good detergency, especially in hard water,evenintheabsenceofphosphates(Yamaneet al.,1989;Ismailet al., 1998);
• C14, C16 and C18 of methyl esters have thebestdetergency(Okumuraet al.,1976;Ahmadet al.,1997;1998;2004);and
• biodegradability(Ghazali,2002).
Similarly, fatty alcohol ether sulphates (FAES)areanionic surfactants which canalsobederivedfrom palm oil. These derivatives are extensivelyused in the production of washing and cleaningproducts.TheobjectiveofthisstudywastodevelopasuitableMES/FAESpremixfortheproductionofliquid detergents. The premix was selected basedon the ternary phase diagram for these products.Possible synergistic detergency effects might be
INTRODUCTION
Surface-active agents or surfactants are used inmany commercial products such as cosmetics, aswell as personal care and household products.Methyl ester sulphonates (MES) are a new classof anionic surfactants which are derived frompalm oil. With the banning in Malaysia of non-biodegradeablebranchedalkylbenzenesulphonate(BAS) detergents, producers of detergent-basedproductshavenowswitchedtolinearalkylbenzenesulphonates (LABSA). One of these, MES, hasreceived a lot of attention as an active ingredientinwashingandcleaningproducts foravarietyof
Keywords: methyl ester sulphonate premix, fatty alcohol ethoxylates, liquid crystalline structure, stability test, detergency.
Date received: 20 April 2010; Sent for revision: 22 September 2010; Received in final form: 12 November 2010;
Accepted: 19 April 2011.
Journal of Oil Palm Research Vol. 23 August 2011 p. 1051-1054
ABSTRACT
We describe palm-based methyl ester sulphonate premixes, which are mixtures of methyl ester sulphonates
(MES) and fatty alcohol ethoxylate sulphonates (FAES), and their application in liquid detergent formulations.
The best ratios of these compounds were obtained from ternary phase diagrams of MES, FAES and deionised
water at 70ºC. The phase changes – from isotropic to liquid crystalline regions – were observed visually
using polarised film, and the liquid crystalline birefringent optical patterns were subsequently confirmed
using a polarising microscope. Based on the phase diagrams obtained, the optimal liquid crystalline region
was selected for the preparation of a palm oil-based premix. Stable premixes can be used to produce liquid
detergent products such as dish-washing liquids, laundry detergents, hand washes, kitchen cleaners and floor
cleaners. The active levels of the palm-based MES premixes were measured using an autotitrator for dish-
washing liquid formulation. The physical stability of the model dish-washing liquids (DWL) was assessed
by conducting stability tests at room temperature (24oC) and also at 45oC, over a three-month period. Other
properties such as detergency, foaming power, pH and viscosity were measured, and comparisons were made
with current typical commercial products. A dermal irritation assay confirmed that the product is non-irritant
to the skin.
Journal of oil Palm research 23 (august 2011)
1052
expected for the correct phase behaviour of suchmixtures.
MATERIAL AND METHODS
Materials
MESofchainlengthC16-C18(activeingredient85%,disalt4%)werepurchasedfromtheMalaysianPalmOilBoard(MPOB).FAES,glycerineandfattyacidalkanolamidewerepurchasedfromOrionSdnBhd,Malaysia.SuitablepreservativesandperfumeswerepurchasedfromDCMSdnBhd,Malaysia.
Methods
Constructing the MES/FAES ternary phase diagram. VariousratiosofMESandFAESandwater,from0%to100%,withatotalweightof0.5gforeach,weremixedin10mltesttubes.Thetubeswereplacedinawaterbath (Haake)maintainedat70oCinorderto melt the mixtures.Approximately 0.01% waterwasaddedtoeachsample,andthenthemixtureswerehomogenisedbyvortexing(VelpScientifica).The samples were remelted and centrifuged(Universalcentrifuges)at5000rpmfor15min.Eachsample was heated and centrifuged at least threetimes, and then allowed to equilibrate in a waterbath for at least 1 hr. The samples were checkedvisually through a cross polariser for separationafter centrifugation. The phase behaviour of themixtures for the isotropic and anistropic regionswas identified visually through a cross polariserandthenbypolarisedmicroscopy(OlympusAX70)incombinationwithaheatingstage,according toIsmail(2002).
Selection of the region in the ternary phase for MES premix formulation. Selection of the MES premixformulationswasbasedontheliquidcrystalregionintheternarysystemplotted.
Active ingredient in MES /MES premix/MES premix in dish-washing liquid. The percentages of activeingredient inMES,MESpremix andMESpremixinadish-washing liquid (DWL)weredeterminedusinganautotitratorwithHyamine1622asatitrant(MetrohmMethod).
Physical properties of MES premix and MES premix in DWL.a. Stabilitystoragestudies
The MES premix in the DWL samples wasevaluated at 45oC, and also at room temperature(24oC), over three months. The samples weremonitored through visual observations for anyappearance of separation. Samples that showedseparation were noted as NS (not stable), whilethosethatwerestablewerenotedasS(stable).
b. ViscosityTheapparentviscosityof theMESpremixand
MESpremixinDWLsampleswasmeasuredusingaBrookfieldviscometerwithspindleNo.3orNo.4at30rpm.
c. FoamingpropertiesA2-litrebeakerwasfilledwith200mldistilled
waterand0.2gDWLwasadded.Usingafabricatedperforatedstainlesssteelpropeller,thesolutionwasstirredfor1minat1300rpm.Thetopandbottomlevelsofthefoamwererecordedimmediately.Thedifferencebetweenthetwolevelsgavethevolumeof foam formed or the foaming power (foamheight). The solution was left standing for 5 min,afterwhichthetopandbottomlevelsofthefoamwere again recorded. The difference between thetopandbottomlevelsindicatedthefoamstability.
d. pHA1%w/vsolutionwaspreparedusingeachtest
sample,anditspHmeasuredwithanMP220pHmeterat24ºC.
e. CloudpointThirty grams of a sample were poured into
a test tube. The test tube was stoppered with arubber bung which had a thermometer inserted.Thetesttubewasplacedinanicebathat-21oC.Thetemperature reading was noted when the sampleturned cloudy as the temperature of the sampledecreased.
f. DetergencypowerThe detergency performances of the DWL
sampleswereevaluatedusingasoiledglassplate.The detergency performances were comparedto the performances of two commercial DWLsamples available in Malaysia. The percentage ofdye removal was calculated based on Leenert’simproved detergency test (Japanese method) asshownbelow:
Detergency=washwithCHCl3withoutsample–wash withCHCl3withsample (CHCl3 –sudan)–(CHCl3+sudan+oils)
Formulationsi) AtypicalformulaforDWLconsistsof:
Deionisedwater upto100g MESpremix 8-10g Glycerol/propyleneglycol 5-20g Lemon(fragrance) 0.5-1.0g Water-solublepreservatives 0.01-0.05g
ii) PreparationofMESpremixesandMESpremixesinDWLThe MES premixes were prepared by mixing
the three ingredients (MES, FAES and deionised
1053
PALM OIL-BASED METHYL ESTER SULPHONATE PREMIXES FOR USE IN DISH-WASHING LIQUIDS
water) at varying percentages at 70oC. They werecoded as MES premix (MESPM) MES PM1, MESPM2andMESPM3.ThepourableviscositysampleofMESPMwasselectedforDWLpreparation.Thefinal product was measured for storage stability,viscosity, foaming power, pH, cloud point, anddetergency.
RESULTS AND DISCUSSION
Ternary Phase Diagram of MES, FAES and Deionised Water
ThebehaviouroftheMES,FAESanddeionisedwater mixtures was plotted in a phase diagram(Figure 1). The ternary mixture of MES and co-surfactant (FAES) with deionised water revealedtheformationoflamellarliquidcrystalsatvariousconcentrationsandratiosbetweenMESandtheco-surfactant(FAES).Thiswasnotedastheappearanceofbirefringenceinthesample.Atthecentreofthe
phase diagram, the phases showed a transitionfrom the liquid crystalline phase (LC) to a two-phaseregionandthentoan isotropicregion(L1).TheliquidcrystallinephasewasfurtherconfirmedwithapolarisingmicroscopeasshowninFigure 2.
Selection of Composition for MES Premix
Thecriteriaforselectingthecompositionpointswere ahigher percentage of surfactant anda lowpercentageofco-surfactantintheliquidcrystallineregionasshowninFigure 1.
MES Premixes
Four MES premixes were prepared and codedas MES PM1, MES PM2 and MES PM3. Table 1 showstheviscositiesandactiveingredientsoftheMESPMseries.Basedonviscosity,MESPM2wasselected for the DWL preparation, because it wasneithertooliquidnortooviscous.
MES Premix in DWL
MES PM2 was selected for the preparationof a dish-washing liquid (DWL PM 001). Table 2 showstheperformanceofDWLPM001,DWL002(which was without the premix) and two typicalcommercialsamples.
The results in Table 2 indicate a higher cloudpointforDWLPM001thanforDWL002andthecommercialsamples.ThiswasduetothephysicalcharacteristicsofMES itself.However, apreviousstudy (to be published later) has shown thatsynergisticeffects inloweringthecloudpointcanbeachievedbycombiningthetwodifferentactives(MESandlinearalkylbenzenesulphates)atspecificpercentages. Higher detergency performance wasfound in DWL PM 001 than in DWL 002 and thecommercial samples. DWL PM 001 had liquidcrystals that can stabilise the system. Anotheradvantage is thatMESPMcanbean intermediatestockofrawmaterialforpreparinganyothertypeofliquiddetergent.Alltheproductswerefoundtobe non-irritant as shown in Table 3 and stable forthreemonthsatpH7.
TABLE 1. METHYL ESTER SULPHONATES (MES) PREMIX PROPERTIES
MES premix
Viscosity (cps) (Brookfield)spindle/rpm Active ingredient
(%)Remarks
4/30 4/60
MESPM1 * * 35.4 Too viscous
MESPM2 9490 8750 25.4 Pourable
MESPM3 92 98 15.2 Too liquid
Note:*cannotmeasured–tooviscous.
Figure 1. Ternary phase diagram of methyl ester sulphonates (MES) with fatty alcohol ethoxylate sulphonates (FAES) as co-surfactant and deionised water at 70°C.
Figure 2. Typical appearance of the liquid crystal and isotropic regions as seen in the polarizing microscope.
Liquidcrystalregion Isotropicregion
FAES
MES
Liquidcrystal
Isotropic
2Phases
Deionisedwater
Journal of oil Palm research 23 (august 2011)
1054
CONCLUSION AND RECOMMENDATION
MES premixes were successfully developed as newintermediaterawmaterialsforthepreparationof liquid detergents. Further improvement onthe properties could possibly be achieved by substituting MES with LABSA at a specificpercentagetoobtainthecorrectcloudpoint.
ACKNOWLEDGEMENT
TheauthorswishtothankSimeDarbyPlantationSdnBhdforpermissiontopublishthisarticle.
REFERENCES
AHMAD S; ISMAIL, Z and SAMSANI, J (1998).Washing behaviour of palm-based sulphonatedmethylester.J. Amer. Oil Chem. Soc.
AHMAD, S; ISMAIL, Z and SAMSANI, J (1997).Palm-basedsulphonatedmethylestersandsoap.J. Oil Palm Research Vol. 10:15-34.
TABLE 2. PERFORMANCE OF DISH-WASHING LIQUIDS
ParameterDWL PM 001 at 8%
active ingredient
DWL 002 without PM at 8% active ingredient
Commercialsample 1
Commercial sample 2
Detergency(%) 92 87 89 89
Cloudpoint(oC) 13 8 -10 8
Foamheight/stability 1125/950 1150/970 1175/990 1200/1000
pHat24oC 7.0 7.0 7.8 7.3
Storagestability(45oCand24oC)
S S S S
Dermalirritation*assay Non-irritant Non-irritant Non-irritant Non-irritant
TABLE 3. DERMAL IRRITATION ASSAY OF DISH-WASHING LIQUIDS
SamplesDose(mg)
HIE score
Predicted dermalirritancy
classification
DWLPM001DWL002Commercial1Commercial2
125125125125
0.000.001.070.92
Non-irritantNon-irritantNon-irritantNon-irritant
AHMAD, S; SIWAYANAN, P;ABD MAURAD,Z;ABDULAZIZ, H; KASSIM SHAARI, N Z andISMAIL, Z (2004). Methyl ester sulphonates palmstearin.Paperpresentedatthe4thChinaSurfactant,PersonalCareandHomecareMarketsConference.
GHAZALI, R (2002). The effect of disalt onbiodegradability of methyl ester sulphonates(MES).J. Oil Palm Research Vol. 14: 45-50.
ISMAIL,Z(2002).Association Behaviour and Rheology of Palm-based Emulsion Using Sugar-based Emulsifiers. Ph.Dthesis,UniversitiPutraMalaysia.
ISMAI, Z;AHMAD, S and SAMSURI, J (1998).Palm-basedsulphonatedmethylestersandsoap.J. Oil Palm Research Vol. 10 No. 1: 15.
OKUMURA, O T; SAKATANI, and YAMANE(1976).Mechanismofsulfonationoffattyacidesterswithsulfurtrioxideandpropertiesofalpha-sulpfofatty acid esters. Comite International des denves Tensio-actives:225-237.
YAMANE,IandMIYAWAKI(1989).Manufacturingprocess of α-sulphomethyl esters and theirapplicationtodetergents.Proc. of the 1989 PORIM International Palm Oil Development Congress. p.132-141.
YONEYAMA,Y(1996).Palmoleochemicalsforusedin detergent-lion’s prespective on the applicationofmethylestersulfonate.Proc. of the 1996 PORIM International Palm Oil Development Congress. p.515-524.
Top Related